ENB - REGION 4 NOTICES

Completed Applications
Consolidated SPDES Renewals

Notice of Approval of A Comprehensive Performance Test (CPT)

NEW YORK STATE DEPARTMENT OF ENVIRONMENTAL CONSERVATION
Notice of CPT Schedule

Applicant: Norlite Corporation
628 South Saratoga Street
Cohoes, New York, 12047

Permits/Application Numbers: 6 NYCRR 373 Hazardous Waste Management Permit.
EPA I.D. No: NYD080469935
DEC Permit No.: 4–0103–16/16–0
Title V Permit No.: 4–0103–00016/00048

Project Location/Description: Norlite Corporation is located at 628 South Saratoga Street in Cohoes, New York and operates two Light Weight Aggregate kilns (LWAKs) a/k/a kiln #1 & kiln #2 that incinerate liquid hazardous wastes as fuels. Norlite Corporation is required to conduct a comprehensive performance test (CPT) to demonstrate compliance with new air emission standard in the Maximum Achievable Control Technology (MACT) rule for hazardous waste combustors, promulgated by the United States Environmental Protection Agency and adopted by the New York State Department of Environmental Conservation. The Norlite Corporation has submitted a CPT Plan narrating detailed testing procedures to be followed during the test. The Norlite Corporation has also submitted a Continuous Monitoring Systems (CMS) Performance Evaluation Test (PET) Plan as required by the MACT Rule. Based on the review of these plans, NYSDEC approved both the CPT and the CMS PET plans with conditions on February 27, 2004. The CPT was performed on March 2, 2004 on Kiln #2. Pursuant to 40 CFR Part 63.1207(e)(2) the notice was published in both ENB and local newspaper announcing this test.

One of the conditions for the February 27th, 2004 approval of the CPT & CMS PET plans was that Norlite must perform a CPT also on Kiln #1 to demonstrate compliance with the MACT standards if the CPT test results from Kiln #2 show that the emissions are above 75% of the MACT limits. This condition was set forth in the approval to provide confidence that both kilns are in compliance with the MACT standards through a test on one kiln instead of on both. Through a letter dated May 27, 2004, Norlite notified the Department that, although the air emissions measured during the March, 2004 testing conducted upon Kiln #2 met the MACT standards, the Dioxin emissions are not within 75% of the limit stipulated in the approval letter, thus prompting the need to measure dioxin emissions on Kiln #1 also to demonstrate its compliance with MACT standards for dioxins. Additionally, Norlite‘s letter requested from the Department an amendment to the previously approved test plan to repeat the CPT on Kiln # 2 for MACT parameters other than dioxin for establishing a more feasible venturi pressure drop condition for routine operations. NYSDEC reviewed and approved the 1st amendment the CPT plan on May 27, 2004 with conditions. The supplemental CPT was performed on June 2, 2004 on Kiln #1 (Dioxin) & #2 (Hcl/Cl2, particulate & metals). Pursuant to 40 CFR Part 63.1207(e) (2) the notice was published in both ENB and local newspaper announcing this test.

Through a letter dated June 29,2004 Norlite informed that Kiln #1 failed to meet MACT standards for Dioxin emissions which prompted the need to modify the operating conditions (i.e. lower the heat exchanger exit temperature & chlorine feed rate) and repeat the CPT for dioxin. Based on a review of the above mentioned letter, NYSDEC has determined that it is acceptable and therefore, has approved the 2nd amendment to the CPT plan on July 1st, 2004 with conditions.

It should be noted that the approvals of two amendments are based solely upon assertions made by Norlite regarding the March 3rd, & June 2nd, 2004 CPT results and does not necessarily mean Department approval and acceptance of the March & June 2004 results. Upon receipt of the detailed reports for the March, June & July 2004 tests, the Department will independently evaluate them for both kilns‘ compliance with all MACT standards.

This notice is made pursuant to 40 CFR Part 63.1207(e) (2) of the MACT Rule which requires the Norlite Corporation to notice this approval along with the tentative test schedule and make the approved CPT and CMS PET plans available for public review.

Tentative Test Schedules: Scheduled commencement date of CPT: July 20, 2004

Scheduled Completion Date of CPT: July 21, 2004

DEC Contact: William J. Clarke, Regional Permit Administrator, NYSDEC Region 4 Office, phone: (518) 357-2069, or Mr. Parag Amin, NYSDEC, Division of Solid & Hazardous Materials, 625 Broadway, 8th Floor, Albany, NY, 12233–7251; Telephone:(518) 402–8609.

Norlite Corporation Contact: William Morris, VP Environmental Affairs, Norlite Corporation, 628 South Saratoga Street, Cohoes, New York, 12047, phone: (518) 235–0401.

Document Availability: Copies of the originally approved plan with it‘s amendment and supporting documents are available for review and copying at the NYSDEC Region 4 Office, 1150 North Westcott Road, Schenectady, NY 12306–2014; Telephone: (518) 357–2069 and also at NYSDEC Headquarters at 625 Broadway (8th Floor), Albany, NY 12233-7251, phone:(518) 402-8609. Copies of these plans are also available for public review at the:

Cohoes Public Library
169 Mohawk Ave
Cohoes, NY 12047

Colonie Public Library
629 Albany Shaker Road
Loudonville, NY 12211

Watervliet Public Library
1501 Broadway
Watervliet, NY 12189

Distribution:
J. Reidy, Chief, New York Section, RCRA Program Branch, USEPA
Kathleen Curtis, CEC
Bobby Chase, CEC
Facility Mailing List
Mayor McDonald, Cohoes
Supervisor Brizzell, Colonie
Mayor Carlson , Watervliet
Cohoes Public Library
Watervliet Public Library
Colonie Public Library
William Morris, Director of Environmental Affairs , Norlite Corporation


Negative Declaration

County: Otsego

Lead Agency: NYS DEC

Project Title: Site Preparation, Otsego Reforestation Area #1
Stands A–20, 31, and 32

Contact Person: Paul J. Wenner
NYS DEC
65561 State Route 10
Stamford, NY 12167
phone: (607) 652–7365

Project Location: Otsego Reforestation Area #1, approximately three miles south of Roseboom, Town of Roseboom

Project Description: The action involves a herbicide reduction of ferns, non–commercial tree species and undesirable low valued tree species to allow the natural regeneration of desired tree species such as sugar maple, black cherry, white ash, and red maple. The action is to take place on 73 acres, presently occupied by stands of sugar maple, black cherry, white ash, and red maple.